SCL-0334

3.PLC控制系统中电磁干扰的主要来源有哪些呢？

  (1)来自空间的辐射干扰

  空间的辐射电磁场（EMI）主要是由电力网络、电气设备的暂态过程、雷电、无线电广播、电视、雷达、高频感应加热设备等产生的，通常称为辐射干扰，其分布极为复杂。若PLC系统置于所射频场内，就回收到辐射干扰，其影响主要通过两条路径；一是直接对PLC内部的辐射，由电路感应产生干扰；而是对PLC通信内网络的辐射，由通信线路的感应引入干扰。辐射干扰与现场设备布置及设备所产生的电磁场大小，特别是频率有关，一般通过设置屏蔽电缆和PLC局部屏蔽及高压泄放元件进行保护。

  (2)来自系统外引线的干扰

  主要通过电源和信号线引入，通常称为传导干扰。这种干扰在我国工业现场较严重。

  (3)来自电源的干扰

  实践证明，因电源引入的干扰造成PLC控制系统故障的情况很多，笔者在某工程调试中遇到过，后更换隔离性能更高的PLC电源，问题才得到解决。

  PLC系统的正常供电电源均由电网供电。由于电网覆盖范围广，将受到所有空间电磁干扰而在线路上感应电压和电路。尤其是电网内部的变化，入开关操作浪涌、大型电力设备起停、交直流转动装置引起的谐波、电网短路暂态冲击等，都通过输电线路到电源边。PLC电源通常采用隔离电源，但其机构及制造工艺因素使其隔离性并不理想。实际上，由于分布参数特别是分布电容的存在，隔离是不可能的。

  (4)来自信号线引入的干扰

  与PLC控制系统连接的各类信号传输线，除了传输有效的各类信号之外，总会有外部干扰信号侵入。此干扰主要有两种途径：一是通过变送器或共用信号仪表的供电电源串入的电网干扰，这往往被忽略；二是信号线受空间电磁辐射感应的干扰，即信号线上的外部感应干扰，这是很严重的。由信号引入干扰会引起I/O信号工作异常和测量精度大大降低，严重时将引起元器件损伤。对于隔离性能差的系统，还将导致信号间互相干扰，引起共地系统总线回流，造成逻辑数据变化、误动和死机。PLC控制系统因信号引入干扰造成I/O模件损坏数相当严重，由此引起系统故障的情况也很多。

Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Toyoda Sanyo Denki BA075AF WT A22M Control Board Rev   B Bent Connector
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Toyoda Sanyo Denki PRS-1593D Control Board
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1785-L60B PLC-5/60 Processor Module Series E Rev   J01
Pre-Owned
   2  432  46
  
Free Shipping
Only 1 left!
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1785-L40B/E PLC-5/40 Processor Module Rev   L01 96269476 A01
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51309223-125 Low Level Analog Mux Module MU-TAMT03 Rev   C/E
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51309223-125 Low Level Analog Mux Module MU-TAMT03 Rev   D/E
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51309223-125 Low Level Analog Mux Module MU-TAMT03 Rev   F/G
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW ESAB Oxweld R770-150-580 Two Stage Pressure Regulator 0558010682
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Harris HP741-050-660-B Single Stage Pressure Regulator 741050660
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   York 031-00938D Power Supply Board Rev   None
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Link-Belt MA5310 and M5310TV Cylindrical Roller Bearing Cup and Cone Set
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   PULSATron LPD3SA-PTC1-XXX E Plus Electronic Metering Pump 11 GPD 250 psi
Pre-Owned
   2  432  46
  
Free Shipping
2 Watching
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Wittenstein alpha SP 075X-MF1-5-1E1-2S Servo Motor Gearhead
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Bently Nevada 330101-00-60-10-02-00 3300 XL 8MM Proximity Probe
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Bently Nevada 330101-00-24-10-02-0 3300 XL 8MM Proximity Probe
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Metso D-446-2 2 Piece Flinger Ring Water Deflector for Thomas Foundry Pump
Brand New
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Kraussmaffei KR100 AE9 LS Control Board PCB
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 9782P-04-C2-E0000-BD pH/ORP Analyzer Controller
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse Emerson 5X00109G01 Ovation Analog Input Module Rev   02
Pre-Owned
   2  432  46
Was:  Previous Price   3  474  95
  
Free Shipping
30% off
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   York ISN 371-03640-000 Display Module with Keypad
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Bosch PV25 0811 405 005 Proportional Valve Driver
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Basler Electric 9 1747 00 110 Min / Max Limiter Assembly w/o Cover
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Rosemount Model 5100A CO Analyzer Control Unit 1U05699G01
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Unbranded Recycle Pump Discharge Valve Flange Retainer 19-1/8" O  D 11" Bore
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Yokogawa PU40-1N Power Supply Module
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Dodge 037538 Tapered Roller Pillow Block Bearing Ser   517 Style TAF
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   3 HP Honeywell NXL0030A1205 Variable Frequency Drive 380-500V
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB C86-94639 Safe Flame DFS TUV Sensor Module Assembly
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-ENET/A Ethernet TCP/IP Communications Interface K01
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Cash Acme Type "E-Series 3" Pressure Regulator 1" Pipe Size 300 PSI Max  
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Siemens 4700-DRMC3-11HN Power Meter Unit
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   General Electric DS3800HRDA1D1D C-ESS Control Board 6BA04
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Flowtronics FTH-150-502 BVD-4 Bidirectional Proportional Valve Control Card
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fanuc A20B-1004-0810/05B Spindle Drive Control Board
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Unbranded Idler Sprocket Roller 5-3/8" Diameter 15/16" Length
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Foxboro 870EC-TFXXU-N*A Electronic Transmitter St  A Ref   No   15511A01
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   DECA Products Inc   MC-4691 Vibrator Control Box 460VAC 60Hz 3Ph 1  6A 1/3 HP
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-ENET/A Ethernet TCP/IP Communications Interface L01
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   DPMC 8650C23 Firing Control Interface Module Rev   02 8650C22
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1771-OWN PLC-5 Selectable Contact Output Module
Pre-Owned
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Yokogawa EJA530A-EAS7N-02EE/FF1/D1 DP Harp Pressure Transmitter no box
   2  432  46
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Hubbell KS-17P8-G-P2-F1-QS Kemlux Industrial Lamp Ballast Tank
   2  432  46