PXIe-6536现货 in stock! 欢迎来电咨询~！！

PXIe-6536,

PXIe-6536

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

　　1 引言

　　纺丝机纺出的涤纶原丝需经过牵伸定型后,才具有一定的纤度、强度、伸度和其它的物理性能。VC443A牵伸加捻机用于涤纶复丝生产过程中牵伸加捻工序。牵伸丝为低捻复丝，可直接或经加弹工序后供绸厂使用。它的电气部分由电源控制系统、程序控制系统、锭子交流变频调速系统、热盘控制系统、热板控制系统组成。随着机电一体化技术的发展，对系统的可靠性要求愈来愈高，因PLC具有控制可靠、体积小、功能强、速度快,组态灵活和可扩展性的特点而得到了广泛的应用，成为自动化系统中的基本电控装置，故VC443A牵伸加捻机选用PLC可编程控制器，实现了生产的自动控制。

　　2 PLC选型设计

　　系统选用了日立公司的产品:E-64HR可编程控制器,作为主控单元，它有64个输入/输出点,其中40个开关量输入点，24个输出点，内置式电擦除EEPROM可以保护用户方便的完成程序和参数的修改和存储, PLC根据各输入点所接按钮，接近开关，接触器等电器信号的状态以及编制的软件程序自动控制各电机，电磁阀，指示灯等，完成整个生产的工艺动作程序，钢领板换向及成型自动控制。E-64HR具有多种编程工具:通用编程器PGMJ-R和标准编程器PGNJ等，体积小携带方便，可在现场实地进行程序调整和传送。全部控制程序约276条，可见该系统软硬件资源得到了相当充分的利用。

　　3 VC443A牵伸加捻机工艺

　　3.1 输入信号

　　VC443A牵伸加捻机控制系统的输入信号:主令按钮、限位开关、接近开关、钮子开关、拨盘开关的投入信号，全部为直流输入，共有40点。

　　3.2 输出信号

　　控制的负载主要分成三类:一是7台交流电机:牵伸双速电机M1、油泵电机M2、靠模升电机M3、靠模降电机M4、移丝电机M5、锭子电机M6、风机M7;二是用于控制钢领板升降及侧压辊压差的电磁阀;三是信号灯;四是计数器，共有24点，全部为继电器接点输出信号。

　　3.3 开车主要控制过程

　　(1) 按“油泵开”按钮SB7，使接触器KM5吸合， 油泵开指示灯亮, 油泵电机M2运转。(程序器的输出50对应的LED发光)。

　　(2) 按“低速开”按钮SB9。

　　●辅助接触器KA1吸合，锭子低速运转。(程序器的输出51对应的LED发光)

　　●程序器控制下，使计数器复零，进入准备工作状态，内部定时器T01 T02接通，使钢领板强迫进入废丝盘位置，待TO0延时到断开快速阀YV3，钢领板在程序器控制下微动。(程序器的输出76、65对应的LED发光，延时到熄灭，66、67对应LED交替发光)

　　●定时器TO1延时到，使接触器KM3吸合，牵伸双速电机M1带动牵伸罗拉和上下牵丝盘低速运转，低速指示灯亮，进入挂丝阶段。(程序器的输出52对应的LED发光)

　　(3) 按“高速开”按钮SB11。

　　●辅助接触器KA2吸合，使锭子高速运转。(程序器的输出53对应的LED发光)

　　●程序器控制使电磁阀YV4断电，侧压辊加压。(程序器输出64对应LED发光)

　　●定时器T02接通，延时到后接触器KM4得电，牵伸双速电机M1切换为高速运转，高速指示灯亮，继电器KA3吸合，移丝电机M5运转。(程序器输出54对应的LED发光。55对应的LED发光)

　　●定时器T03延时到后，钢领板强迫上升，靠模上撞块使底部打结开关SA2接通，定时器T04得电，使上升阀失电，实现底部打结，T04延时到上升阀YV1/1再次得电，强迫钢领板快速上升，进入正常牵捻区，待T05延时到后切断快速阀YV3，钢领板在程序器控制下，以正常速度运动，同时接通继电器KA4，靠模升电机M3运转，带动靠模缓慢上升，计数器开计长(程序器56对应的LED发光。65对应的LED在接通快速阀时发光，74对应的LED发光，有计长信号时发光指示)。

　　至此开车过程结束，机器进入正常纺丝。
 

Application-specific products 1404-M605A-DNT MASTER MODULE FOR POWERMONITOR

Operator Interface 2711P-T15C4D2 PV PLUS 1500, TOUCH, ENET, DC PS, EXT MEM

Support 9301-2SE3400DES SUPT RENEWAL CONTRACT FOR 93012SE3400DE

Support 9354-OD100S 9354-OD100 SOFTWARE SUPPORT CONTRACT RENEWAL

Support 9393-EGLX500R SUPT REINSTATEMENT CONTRACT FOR 9393EGLX500

DeviceNet Products 1734-OX2 24V DC COIL N.O./N.C. DPST RELAY MODULE

RSI Software Products 9301-2SE2300U2R UPGRADE: OUT-SUPT: RSVIEW WORKS 150 TO 1500

RSI Software Products 9358-BANT60U3 UPGRADE: IN-SUPT: RSBATCH ARCHIVER 30 TO 60

RSI Software Products 9356-STD2350U2 UPGRADE: IN-SUPT: RSSQL STD 300 TO STD 5000 TAG

Motion Control Y-1003-2-H00AA MOTOR,SERVO,0.35 NM,4500RPM,ENCDR,230V,1.04KG

510-1000-004 POWER SUPPLY 24VDC 1.3AMP

IC200CPU001 CPU 12K USER PROG 1.80MSEC/K BOOLEAN ONE RS232 AND ONE RS485 SERIAL PORTS

IC694MDL754 12/24VDC Output (0.75 amps per point)Module 32 point. The module can be used on expansion bases (uses high speed serial bus). The module requires a terminal block (IC694TBB032 box style or IC694TBS032 spring clamp style terminal block).

MSI-WEB-25 Web or Excel Reporting Clients 25 Pack

cRIO-9031

PCM-3343F

ADTECH ADT-8940A1

IPC AS-3262

ACE-932A

VPM-8100LQ-000

BCM5761 488293-001

1492-SPM2C630 MCB Supplementary Protector 63 A

软启动器 3RW30362BB14

电机启动器 3VU16400CG00

150-F251NBR SMC Flex Smart Motor Controller

1732E-16CFGM12P5QCR ArmorBlock 16 Point Configurable QC

1771-P5EK 1771 Power Supply

193-EEDP E1 Plus 3.2-16 A IEC Overload Relay

199-MSMA48 Surge Suppressor

2090-CPWM7DF-08AA90 MP-Series 90m Standard Power Cable

2097-F4 Kinetix 300/350 4.40 A Line EMI Filter

EDS-308-T C1 D2 8-port Unmanaged 10/100 Switch (-40 to 75 deg C op temp)

GFK-1504 Manual VersaMax Modules, Power Supplies, Carriers, and Cables

IC220ALG220 ANALOG IN, 15 BIT, VOLTAGE/CURRENT, 2CH (REQUIRES 1 IC220TBK061)

IC647CGMS00 GM Server Site License (not for general use)

IC647PRTOSIC Proficy Portal OSI PI Connector (M1 Key)

IC693DSM302RR Series 90-30 Motion Mate DSM302 Motion Controller, 2 Axes

IC756ADV001K-97 DV Development - AIX Op Sys Addt'l User, Korean, Version 9.7

MSI-IGC-43 7 Day x 24 Hour Support / GlobalCare-43

SLC/1746 System 1746-RT34 TERMINAL BLOCK FOR THE 1746-NT8 MODULE

Distributed I/O 1738-OB4EM8 24VDC 4 SOURCING OUTPUTS WITH M8 CONNECTORS

Communications 2760-A485 CONNECTOR, DH485 MULTIDROP FOR NEMA TYPE 1 DECODER

Operator Interface 2711-NP2 MOUNTING CLIPS PV600 KEY, 900, 1000

Support 9302-SCAR SUPT REINSTATEMENT CONTRACT FOR 9302SCA

Support 9324-RL5300ITR SUPT REINSTATEMENT CONTRACT FOR 9324RL5300IT

DeviceNet Products 2706-P44C INVIEW MESSAGE DISPLAY. 1 OR 2 LINE

RSI Software Products 9301-2SE335DEU2R RSVIEW32 RUNTIME 300-5K UPGRADE OUT-SUPT(DE)

RSI Software Products 9371-DETPLUS DETAILER BONUS MODULE

Motion Control MPG-A025-031M22 MOTOR,SERVO,GEAR RATIO 31,100NM,168RPM,MULTI,230V

Silver Series 1785-V80B VME PLC5/80 CONTROLLER, 100K WORD SRAM

HE693RLY160 16 point, 5A Relay Output module for GE Fanuc high density Output module IC693MDL752. Requires HE690CBL102 or HE690CBL105 ribbon cable.

IC660BRD025 Genius 32point 5/12/24 Vdc Sink Block for Redundancy "T" Configuration

QPICGAE0000 10.4" Color TFT, GE Fanuc, Ethernet, CF Card, 110 VAC

ST-5252 STXi Serial Interface module RS-232 , 2 Channels,32 Bytes,

USB-8472s

PCI-1610

新汉PEAK735 (LF)

fuji is70b

SBC8253

MV5XX

1492-SJMD5-12 IEC Term Blck 12 pole Side Jumper

人机界面 6AV6545-0BC15-2AX0 TP170B 触摸屏，彩色，6 英寸，320? 240

6ES78331FA130YA8

1497B-A14-M14-0-N Control Power Transber

1606-XLS480E-3C Power Supply XLS 480 W Power Supply

1769-IA8I CompactLogix 8 Pt 120VAC D/I Iso Module

189-AL11 MCB Accessory Auxiliary Contact

194R-HM1 194R 100-400 A Operating Handle

2090-CPBM7DF-12AA30 MP-Series 30m Power and Brake Cable

2090-XXNPMP-16S20 MP-Series 20 m Length Power Cable

CBL-30-BT-30 Brake cable for MTR-3S or MTR-3N series servo motors with brake. 30 feet

GF-0203R Connecting FlashCable to Fowler (Chinese with RS-232).

IC200TBX210 Tool box, 10 point, (IC200NDR001) 24VDC In/Relay Out, 24VDC Powered (r equires an external 24VDC Power Supply), VersaMax SE (IC200SET001) wit h all software, cables and manuals (IC640VPS002 and IC646MPM001).

IC646TBSPMPS600 Smart Process Monitoring Process+ server 600 loops

IC647NSG000 Siemens AS511 OPC Server

IC693ACC332 TBQC Base for IC693MDL940

IC752CAB201 AB SLC500 cable for DataPanel 150/160/240

IC800VMCP1050 Power cable for 1 kW VersaMotion servo motor- 5 meter

SLC/1746 System 1746-OW8 RELAY OUTPUT MODULE FOR PROGRAMMABLE CONTROLLER

Industrial Computers 6189V-ACPS AC POWER SUPPLY ATX STANDARD

Application-specific products 1400-PD52A POWERMONITOR DISPLAY MODULE

Operator Interface 2711-B6C3 PV600 COLOR KEY&TOUCH, DH485 & RS232 PRINT

Support 9301-2SE2400ESR SUPT REINSTATEMENT CONTRACT FOR 93012SE2400ES

Support 9307-EM8MGRS SUPT RENEWAL CONTRACT FOR 9307EM8MGRENE

DeviceNet Products 1734-IB2 24V DC 2 CHANNEL SINK INPUT MODULE

RSI Software Products 9301-2SE250ZHU2R RSVIEW32 WORKS 1500-100K UPGRADE OUT-SUPT (ZH)

RSI Software Products 9358-BNT60U3 UPGRADE: IN-SUPT: RSBATCH 30 TO 60

Motion Control MPL-B330P-RJ22AA MOTOR,SERVO,4.18 NM,5000RPM,RSLVR,460V,5.9KG

Motion Control 2090-U3BK-D4401 BREAKOUT BOARD KIT,CONTROL,CN1,ULTRA 3000,1M

GFK-0685 Series 90 PLC Flow Computer User's Manual

IC646CNU000 CIMPLICITY Client for Microsoft Windows User Package

MSCPX-312806NT Marathon Exp CPU,566 MHz CPU, 128M, 6G, Win NT, 2 PCI/ISA , 1 PCI, 1ISA

PSPC-DC50/E-220 Prof Shop Floor SPC DC 50 User eSig 220v

PXIe-2524

AverMedia 圆刚 V1A3-D

FSP350-60EVML

34-0877-01

FYI-597

HK08V4-A

1492-N36 TERM BLCK End Barrier High Density

回路闭环控制模块 6ES7355-0VH10-0AE0 FM355C，4 回路闭环控制模块，8DI/DO，4AI，2个 20pin 前连接器

行程开关 3SE53223SE23

TIA 博途 WinCC 选件 6AV2107-2KG00-0BD0 SIMATIC WinCC WebNavigator for Runtime Professional Powerpack 5 -> 10 Clients

1585J-M8HBJM-50 RJ45 Ethernet Media

1760-IB12XOW6I Pico DC Expansion Input/Output Module

188-K2C005 Miniature Circuit Breaker 0.5 A

194L-A12-1754 12A 194L Load Switch

2090-CHBP8S8-12AA12 Kinetix 6000M IDM Hybrid Cable

2090-UXTBMP-18S12 MP-Series 12 m Length Brake Cable

BC647MPP050 Logic Developer PLC Professional 50 pack with Proficy GlobalCare Complete with USB Hardware key

GC647IFPRSRUNLMT GCC iFIX Profsnl SCADA Unlmt Srv

IC200CHS102 I/O interposing disconnect style, 16 point expansion

IC646MSP005 Logic Developer State Professional 5 Pack

IC647IFSTRN00075K iFIX Standard HMI 75 I/O Runtime (M1 Kit Part)

IC670CHS003 I/O Base, Connector Style

IC697CSE925 State Logic CPU, 64MHz, 80486DX2

IC800SKCI030 Interface cable to connect an S2K auxiliary I/O connector to the 44A726268-001 terminal block. 3 meter

ControlLogix/1756 System 1756-OG16 0-5 VDC TTL OUTPUT (LOW TRUE) 16 PTS (20 PIN)

Industrial Computers 6182H-12BEH15B VVCE 1250, KEY/TOUCH, EXT MEM, CNET, AC

Process Control 1757-FIMUPG080 FIELDBUS LICENSE UPGRADE, 80 FIMS

Operator Interface 2711P-RGT12 PV PLUS/VVCE PROTECTIVE ANTIGLARE OVERLAYS QTY 3

Support 9355-WABOEMENS SUPT RENEWAL CONTRACT FOR 9355WABOEMEN

Support 9354-SS100R 9354-SS100 SOFTWARE SUPPORT CONTRACT REINSTATEMENT

ControlNet Products 1788-CNF CONTROLNET LOGIX DAUGHTER CARD

RSI Software Products 9301-2SE2400PTE RSVIEW32 WORKS 32K (PORTUGUESE)

RSI Software Products 9355-WABSNEU3R UPGRADE: OUT-SUPT RSLINX SINGLE NODE TO RSLINX GW

Motion Control MPL-A330P-HK24AA MOTOR,SERVO,4.18NM,5000RPM,ENCDR,230V,BRK,6.1KG

Motion Control 2090-UXNBMP-18S01 CABLE,ULTRA,NON-FLEX,MOTOR BRAKE,MP 1 MTR.

CBL-12-MPS-30 Power Cable, MTR-1221-*-D & MTR-1231-*-D Stepping Motor with S2K, 30 Ft.

IC600PB552RR PDT Prom Board

IC800SKCBVL100 Power/Brake Cable, S2K to 4.5 - 5kW S-Series Servo Motors, 10 Meters

OC647IFESGRNUNLMTM iFIX Optn: ESig & ERec Unl I/O Runtime (M4 Part)

PXI-2206

eTX-Lx15

FSC-1611VD4N

N55-PAC-750W

PCISA-3716EV-R3

PCIe-RTV24

1492-M6X5V1-50 Connection Products

1494U-AC 1494U 30A-100A Crossbar Adapter

软启动器 3RW44532BC44

SIMATIC STEP 7 V14 6ES7822-0AA04-0YA7 SIMATIC STEP 7 基本版 V14 试用授权

1585D-M4UBDE-3 Ethernet Media M12, Patchord

1756-IB16K ControlLogix 16 Pt 12/24V DC D/I Module

1794-TB3TK Flex Terminal Base

194E-E16-1753-4A 16 A 194E Load switch

2090-CFBM4DF-CDAF02 MP-Series 2m Feedback Cable

2090-KFBE7-CAAA MP-Series Feedback Connector Kit

AT-8624FC-10_2 Proficy Process Systems Switch with Two Multi-mode Fiber Modules from Allied-Telesis

GC646TDV915 Proficy GlobalCare Complete for 1500 Point I/O Development / Runtime System.

HMI-AGO-203 ANTI-GLARE OVERLAY 5 inch/ 5 per pack

IC640WMI310RR Series 90 XT/AT Serial Interface Card

IC647HSTSSEO750KM eSignature Option for Historian - Standard Server 750,000 Points (M4 Key)

IC660BSM120RR Bus Switching Module, 24/48 Vdc

IC695ETM001 Ethernet module 10/100 Mbits 2 RJ45 connections one IP address occupies one slot on system base

IC756WRE024E-275 "Runtime License for Windows 1-24 Users, Per User, English v2.7.5"

FlexLogix System 1794-L34 FLEX LOGIX PROCESSOR, 512KBYTES USER MEMORY

PLC-5/1771 System D1771-6.5.7 ANALOG INPUT MODULE(8-BIT)(1771-IE)USER'S MANUAL

Process Control 1757-PLXNU OPEN DATA ACCESS - 1 USER

Operator Interface 2711P-RDT7C PV PLUS 700, TOUCH SCREEN DISPLAY MODULE

Support 6626-NMU2R 6626-NMU2 SOFTWARE SUPPORT REINSTATEMENT

Support 8100-HSRASS SUPT RENEWAL CONTRACT FOR 8100HSRAS

Support F1785-L20C15SERC FIRMWARE UPGRADE FOR 1785-L20C15 PLC5 PROCESSOR MO

RSI Software Products 9301-2SE220FRU1R RSVIEW32 WORKS 150-300 UPGRADE OUT-SUPT (FR)

RSI Software Products 9701-VWSB100DEU1 RSV SE STATION 25 - 100 DISPLAY UPGRADE (GERMAN)

RSI Software Products 9399-HDWAREREFFR HARDWARE INTERFACE CONFIG. USER GUIDE (FRENCH)

Motion Control 2098-DSD-HV100-DN HIGH VOLTAGE DRIVE, 23A/46A, ULTRA3000 W/DNET

BC641VPN950 VersaPro Nano/Micro Edition 50 Seat Site License - Windows Programming Software for VersaMax Nano/Micro PLCs

IC300DIQ622 8 AC Inputs (120 vac), 6 Isolated Relay Outputs (4.0Aper point)

IC752GEIU11 GEF 9030 I/O Master/Scanner for ControlStation CE Iix

MTR-3S46-G-R-B-E-SRR Servo Motor 24V Brake, Seal

PCI-4462

SBC84500/510

COM-840-R-12

BPA-R350-21N

MMC-BDPV81

GV-N610D3-1GI

1492-JG10 10 square mm Ground Terminal Block

1492-WD6 IEC Term Blck 8x47.6x41mm Screw

软启动器 3RW44221BC46

性能信号模块 6ES7 522-5HH00-0AB0 DQ 16：数字量输出模块，继电器 DQ 16x 230 VAC/ 2A ST (RELAY), 35mm 模块，不含前连接器

156-B32CA3 32 A Contactor

1746-IV32 SLC 32 Point Digital Input Module

1786-TPST2T ControlNet Coaxial IP67 TNC T-Tap

193-T1DC47 35-47 A IEC Bibllic Overload Relay

20-HIM-H10 PowerFlex 20 HIM Remote Cable Kit

2090-CSBM1DF-14AF05 Kinetix Cable Single DSL 2090-Series

20AC022A3AYNAEC0 PowerFlex 70 AC Drive 22 A at 11 kW 20A

GA647TRT300 Proficy GlobalCare Assist for CIMPLICITY HMI Server 300 I/O Runtime System

GP647IFUBSTS GCP iFIX iClientTS User Base Support

IC600CM542RR 2K CMOS Logic Memory Module

IC647HSTCSEO100KM eSignature Option for Historian - Enterprise Corporate Server 100000 Points (M4 Key)

IC647WDEM WDE:Woodword Modbus Ethernet

IC693UEX011RR 14pt DC In/Relay Out, AC Pwr. Sup.

IC756RDV001J-99 DV Development - Irix Op Sys Addt'l User, Japanese, Version 9.9

MicroLogix 1200 System 1762-L40AWAR ML 1200 40AC/RLY/AC 2 PORT

PLC-5/1771 System 1771-IJ ENCODER/COUNTER MODULE ASSEMBLY TTL, 5V DC

Distributed I/O 1794-IB32 24 VDC INPUT MODULE, 32 POINTS

Communications 9355-WABOEMDEE RSLINX OEM - GERMAN

Operator Interface D6195-6.5.2FR CONTROLVIEW 300 USER MANUAL (FRENCH)

Support 9358-BEPB10S SUPT RENEWAL CONTRACT FOR 9358BEPBNT10ENE

Support F1756-DNB FIRMWARE UPGRADE FOR 1756-DNB/A MODULE

RSI Software Products 9324-RL0300ESE RSLOGIX 500 STANDARD SPANISH CD

RSI Software Products 9301-2SE3503KOE RSVIEW32 RUNTIME 100K WITH RSLINX (KOREAN)

RSI Software Products 9358-HSTS2300 RSBIZWARE HISTORIAN SERVER - 1500 TAG LIMIT

Motion Control W-3016-N-H00AB MOTOR,SERVO,WASHDOWN,BF,1.7 NM,3000RPM,6.4KG

5601 Greyline Micro MC. 2 Lines, (20) 5MM Chars. LCD. ASCII/Serial Interface. NEMA 4

IC200ETM001 EXPANSION TRANSMITTER

IC695DEM003 RX3i type 3 demo stand. Demo includes, CPU, power supply, Ethernet, b simulator, output, high speed counter, comination analog, Universal analog, and digital servo module, QuickPanel control/View, and S2K amplifier and motor

MTR-1220-0-A-E-0RR Stepping Motor Nema23 Double Shaft

cRIO-9073

PCA-6277VE

MOXA CP-118U

EC0-1815V2NAR

ACE-916A

VPM-8120X-5060

ROBO-8111VG2AR-Q77

1492-SPM2D160 MCB Supplementary Protector 16 A

软启动器 3RW30471BB04

电机启动器 3VU16401CK00

150-F317NZD SMC Flex Smart Motor Controller

1732E-IF4M12R ARMORBLOCK 4 POINT ANALOG INPUT

1771-WA FIELD WIRING ARM 10 TRMLS TIN PLATED

193-EEKG E1 Plus 60-300 A IEC Overload Relay

20-750-2262D-2R PowerFlex 750 115V AC IO Option module

2090-CPWM7DF-10AA02 MP-Series 2m Servo Power Cable

2097-V31PR2-LM Kinetix 350 800W Servo Drive

ENQAM315 Attachable Connector, Stranded Cable

GFK-1868 CIMPLICITY Machine Edition Getting Started

IC220EBI001 Ethernet Network Interface Unit (REQUIRES 1 IC220TBK087)

IC647CSPR005 Proficy Cause+ for Inbligent HMI/SCADA Runtime Server - 5X monitored KPIs