SGM-08A3B4PL

3.PLC控制系统中电磁干扰的主要来源有哪些呢？

  (1)来自空间的辐射干扰

  空间的辐射电磁场（EMI）主要是由电力网络、电气设备的暂态过程、雷电、无线电广播、电视、雷达、高频感应加热设备等产生的，通常称为辐射干扰，其分布极为复杂。若PLC系统置于所射频场内，就回收到辐射干扰，其影响主要通过两条路径；一是直接对PLC内部的辐射，由电路感应产生干扰；而是对PLC通信内网络的辐射，由通信线路的感应引入干扰。辐射干扰与现场设备布置及设备所产生的电磁场大小，特别是频率有关，一般通过设置屏蔽电缆和PLC局部屏蔽及高压泄放元件进行保护。

  (2)来自系统外引线的干扰

  主要通过电源和信号线引入，通常称为传导干扰。这种干扰在我国工业现场较严重。

  (3)来自电源的干扰

  实践证明，因电源引入的干扰造成PLC控制系统故障的情况很多，笔者在某工程调试中遇到过，后更换隔离性能更高的PLC电源，问题才得到解决。

  PLC系统的正常供电电源均由电网供电。由于电网覆盖范围广，将受到所有空间电磁干扰而在线路上感应电压和电路。尤其是电网内部的变化，入开关操作浪涌、大型电力设备起停、交直流转动装置引起的谐波、电网短路暂态冲击等，都通过输电线路到电源边。PLC电源通常采用隔离电源，但其机构及制造工艺因素使其隔离性并不理想。实际上，由于分布参数特别是分布电容的存在，隔离是不可能的。

  (4)来自信号线引入的干扰

  与PLC控制系统连接的各类信号传输线，除了传输有效的各类信号之外，总会有外部干扰信号侵入。此干扰主要有两种途径：一是通过变送器或共用信号仪表的供电电源串入的电网干扰，这往往被忽略；二是信号线受空间电磁辐射感应的干扰，即信号线上的外部感应干扰，这是很严重的。由信号引入干扰会引起I/O信号工作异常和测量精度大大降低，严重时将引起元器件损伤。对于隔离性能差的系统，还将导致信号间互相干扰，引起共地系统总线回流，造成逻辑数据变化、误动和死机。PLC控制系统因信号引入干扰造成I/O模件损坏数相当严重，由此引起系统故障的情况也很多。

Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   TEWS Technologies TVME200-10 VMEbus Carrier Board Rev   A Ver   1  1
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell MU-TSTX03 Smart Transmitter Interface b 51309140-125 Rev   B
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   TransData 8104-VD11 Analog Output Converter Module Ver   2  22
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D KHL36225 Circuit Breaker 225 Amps 600VAC 250VDC
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW ABB Kent-Taylor 326-LT Electronic Transmitter 275 PSIG 25 to 150 InH2O
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   GE Fanuc IC661EPM100J Genius PowerTRAC Electronic Module
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Mizar Inc   VME 8610 Interface Control Board 8610-0-01 Rev   D
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Matrox SX-900/64-8/B2 Graphics Imaging Card
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51402625-175 UCN Digital Input SOE Card HDW: H FW: G
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Taylor Instrument R1-176-LT Electronic Transmitter 146749-B
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Thermo Electron G4-SB500-N Load Cell 500 Pound Capacity
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Yokogawa EJA530A-EAS7N-02EE/FF1/D1 DP Harp Pressure Transmitter
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51304690-100 UCN Digital Input SOE Card HDW: H FW: F
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51304690-100 UCN Digital Input SOE Card HDW: J FW: F
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Bently Nevada 3500/92 Communication Gateway Module PWA 136180-01 Rev   L
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Brooks Instrument MT3810 Armored Metal Tube Flow Meter 3810A14BAPAA1A1
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Unit / Celerity UFC-1665C Digital Metal Seal 1L H2 Multiflo SC15
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Danaher Dynapar M050786 Encoder 62-AADF-0900-AB
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Tucker B 346 E 110 344 Stud Welder Control Board
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Orbisphere Laboratories Model 2606 Oxygen Indicator 29034 2986
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   EHC 9607086 Mod 4 Control Board Assembly 9607087
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fisher Rosemount KJ4001X1-BE1 Delta V 8 Wide Carrier Base Module Rev   L
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fisher Rosemount KJ4001X1-BE1 Delta V 8 Wide Carrier Base Module Rev   J
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Bently Nevada 330705-02-18-10-02-00 3300 XL 11MM Proximity Probe
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Elliott P3850A060 Bearing Half Sleeve
Brand New
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Tucker B 346 A E 110 344 A Stud Welder Control Board
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Satec ETC2002 Inbligent Communication Device Network Communicator
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fanuc A20B-1004-0850/05A Servo Amplifier Unit Control Board
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Emerson OCX 8800 Power Supply Assembly 6A00132G01 Rev   7
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB DSQC 532A I/O Computer Board 3HAC18158-1
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Worthington 232100CJ1 Air Compressor Unloader Valve Assembly
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Honeywell MIDAS-T-001 Gas Analyzer Transmitter Assembly
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Telesis 23490-06 Marking System Controller Control Board Rev   A
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Atlas Copco QCM-T 340 25 Servo Control Module 4240 0337 81 F/W 3  18 S/W 3  1
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Schrader Bellows M08444632 Manual Valve
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Industrial Devices Corporation IDC IM-LMT42 Impulse Microstepping Drive NC
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Brooks MT 3810 Armored Metal Tube Flow Meter 3810A14BAPAA1A1
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   General Electric 36B605218CA-A-X2 SV-1 Drive Module
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Kansai Automation Model KLI Capacitance Level Indicator Amplifier Unit
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Static Controls Corporation 1040-P-03-32-X Operator Interface Panel SCC
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Leeds & Northrup 075706 Preamplifier Module Rev   B
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fisher Rosemount CL6828X1-A1 Provox Smart Device Output 12P1395X032 Rev   D
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   EST Model MVM Multiple Voice Message Module 240359 Rev   D
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Carrier 32GA400504-2 Oil-Sense2 Oil Quality Alert Unit
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-L1/A ControlLogix Processor w/ 1756-M2/A Rev   T01
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-L1/A ControlLogix Processor w/ 1756-M2/A Rev   T01 B01
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-L1/A ControlLogix Processor w/ 1756-M2/A Rev   R01
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-L1/A ControlLogix Processor w/ 1756-M2/A Rev   S01 C01
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Foxboro B0133SH-D Memory Board F8620D L0118WF Rev   A
Pre-Owned
   2  606  21
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Toshiba VT130Q9U4110 Transistor Inverter Drive 11 kVA 10 HP 380-480V
Pre-Owned
   2  606  21