51304518-100

3.PLC控制系统中电磁干扰的主要来源有哪些呢？

  (1)来自空间的辐射干扰

  空间的辐射电磁场（EMI）主要是由电力网络、电气设备的暂态过程、雷电、无线电广播、电视、雷达、高频感应加热设备等产生的，通常称为辐射干扰，其分布极为复杂。若PLC系统置于所射频场内，就回收到辐射干扰，其影响主要通过两条路径；一是直接对PLC内部的辐射，由电路感应产生干扰；而是对PLC通信内网络的辐射，由通信线路的感应引入干扰。辐射干扰与现场设备布置及设备所产生的电磁场大小，特别是频率有关，一般通过设置屏蔽电缆和PLC局部屏蔽及高压泄放元件进行保护。

  (2)来自系统外引线的干扰

  主要通过电源和信号线引入，通常称为传导干扰。这种干扰在我国工业现场较严重。

  (3)来自电源的干扰

  实践证明，因电源引入的干扰造成PLC控制系统故障的情况很多，笔者在某工程调试中遇到过，后更换隔离性能更高的PLC电源，问题才得到解决。

  PLC系统的正常供电电源均由电网供电。由于电网覆盖范围广，将受到所有空间电磁干扰而在线路上感应电压和电路。尤其是电网内部的变化，入开关操作浪涌、大型电力设备起停、交直流转动装置引起的谐波、电网短路暂态冲击等，都通过输电线路到电源边。PLC电源通常采用隔离电源，但其机构及制造工艺因素使其隔离性并不理想。实际上，由于分布参数特别是分布电容的存在，隔离是不可能的。

  (4)来自信号线引入的干扰

  与PLC控制系统连接的各类信号传输线，除了传输有效的各类信号之外，总会有外部干扰信号侵入。此干扰主要有两种途径：一是通过变送器或共用信号仪表的供电电源串入的电网干扰，这往往被忽略；二是信号线受空间电磁辐射感应的干扰，即信号线上的外部感应干扰，这是很严重的。由信号引入干扰会引起I/O信号工作异常和测量精度大大降低，严重时将引起元器件损伤。对于隔离性能差的系统，还将导致信号间互相干扰，引起共地系统总线回流，造成逻辑数据变化、误动和死机。PLC控制系统因信号引入干扰造成I/O模件损坏数相当严重，由此引起系统故障的情况也很多。

Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Allen Bradley 1403-DMA Powermonitor II Display Module Series B FRN 1  10
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ITW Ransburg 74944-100 Rev   E Module A10220-01 Rev   L
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ITW Ransburg 74944-100 Rev   E Module A10220-01
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   GE 6VAF343003B-A2 Variable Frequency Drive 3 HP 460V AF-300
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Sti MS46-30-1215-R-FP-CX1 Light Curtain Receiver 48" 70158-1512
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ITW Ransburg 74944-56 Rev   G Module 74943 Rev   A
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ITW Ransburg 74944-111 Rev   R Module A10220-01 Rev   H
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Sti MS46-30-1215-R-FN-CX1 Light Curtain Receiver 48" 70112-1034
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Sti MS46-30-1045-R-FP-CX1 Light Curtain Receiver 41" 70158-1531
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW NTN 6218LLUC3/EM Single Row Deep Groove Ball Bearing 6218LLUC3/L627
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Cleaver Brooks ControlBus Module 833-2757 CB Hawk
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1791-0A32/B Block I/O Module B01
Pre-Owned
   2  258  72
  
Free Shipping
Only 1 left!
9 Sold
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Digital Monitoring Products PC-0074 R8 Control Board Rev   J
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Digital Monitoring Products PC-0074 R8 Control Board Rev   K
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Ametek Drexelbrook TFL30 Relay Output Vibrating Level Switch
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Matrox MG-1281 Graphics Controller Card MG-1024/8/B Rev   02
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1791-0A32 Block I/O Module Ser   B Rev   B01
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse M300 149D946G02 Over Excitation Protection-3 Sub   5
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51305072-200 I/O Card CLCNIO Rev   F
Pre-Owned
   2  258  72
  
Free Shipping
Only 1 left!
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1791-0A32 Block I/O Module Ser   B Rev   D01
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Ametek Drexelbrook TFL30 Relay Output Vibrating Level Switch TF Series
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1791-0A32 Block I/O Module Ser   B Rev   C01
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Giddings & Lewis 31-50231N14 CPU Board FS054593-0002
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell TC-ODD321 Experion DC Output Module 97067175-A01 Rev   G01
Pre-Owned
   2  258  72
  
Free Shipping
2 Watching
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fujitsu DCA6-MEM1 Flashwave 4300 Processor Card FC9520MEM1
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse 4D33865G01 PCD I/O Auxiliary Power Supply Module Sub 07
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Yokogawa RS42-ON RS422 Interface Module RS42-ON without cover
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Electro-Craft 0670-07-021 Permanent Magnet Motor Tach
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Schroff 60800-424 14 Slot VME I/O Bus Backplane Board
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse 7381A01G04 Ovation Batch Processor Board 8MSP8 Sub AC
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   RiL Model CL6000 Supercal Multimeter
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Superintend VRE-80MUS Residual Current Monitor Unit
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Hubbell KS-17P8-G-P2-F1-QS Kemlux Industrial Lamp Ballast Tank no cover
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 592-EC2BC Solid State Overload Relay Ser  B FRN 3  003 3-15A
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Ametek AC2000 Battery Charger Interface Assembly 196162-001 / 192819A-001
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Ametek AC2000 Battery Charger Interface Assembly 192780-001 / 192819-001
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Bently Nevada Dual Velocity Monitor 3300/55-01-04-02-02-03-00-06-00
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Bently Nevada Dual Velocity Monitor 3300/25-XX-XX-XX-03-01-02-00
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Hach 19180=A=0211 Series 9100 Amperometric Meter 9180/Amp
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Ariel A-15436-A Compressor Discharge Seat DIS VLV SEAT ASSY   140CEX   PRC
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Yaskawa CMPC-CM34C-3 Motionpack 34 Servo Controller
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB DSQC 210 Safety Board YB560103-AM
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse 4D33900G19 Ovation Auxiliary Power Supply Module Sub   14
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1791-0A32 Block I/O Module Ser   B
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Vega SWING61  CUANVXNZX Vibration Level Switch
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1756-L1/A ControlLogix Processor w/ 1756-M1/A Rev   D01
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Vega SWING61  CUANVXNZX Vibration Level Switch 6162825/001
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Schweitzer SEL-311A Protection and Automation Module 0311A00H14254X1
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Premisys 608800-393-600 CPU-3 BCON SS Card Rev   D2
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Fisher RGXBELLX082 Bellows    Kit GX DN50 HASTC/316
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   TRW Nelson LP MP-1 Stud Welder Slot Rack Chassis 66-03-67a
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Moore Industries AOM/IO/TI4/IP[DIN] Temperature Input Module
Pre-Owned
   2  258  72
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 705-C0D103 Motor Starter Series K Size 2 25 HP 600 VAC
Pre-Owned
   2  258  72