620-0054

3.PLC控制系统中电磁干扰的主要来源有哪些呢？

  (1)来自空间的辐射干扰

  空间的辐射电磁场（EMI）主要是由电力网络、电气设备的暂态过程、雷电、无线电广播、电视、雷达、高频感应加热设备等产生的，通常称为辐射干扰，其分布极为复杂。若PLC系统置于所射频场内，就回收到辐射干扰，其影响主要通过两条路径；一是直接对PLC内部的辐射，由电路感应产生干扰；而是对PLC通信内网络的辐射，由通信线路的感应引入干扰。辐射干扰与现场设备布置及设备所产生的电磁场大小，特别是频率有关，一般通过设置屏蔽电缆和PLC局部屏蔽及高压泄放元件进行保护。

  (2)来自系统外引线的干扰

  主要通过电源和信号线引入，通常称为传导干扰。这种干扰在我国工业现场较严重。

  (3)来自电源的干扰

  实践证明，因电源引入的干扰造成PLC控制系统故障的情况很多，笔者在某工程调试中遇到过，后更换隔离性能更高的PLC电源，问题才得到解决。

  PLC系统的正常供电电源均由电网供电。由于电网覆盖范围广，将受到所有空间电磁干扰而在线路上感应电压和电路。尤其是电网内部的变化，入开关操作浪涌、大型电力设备起停、交直流转动装置引起的谐波、电网短路暂态冲击等，都通过输电线路到电源边。PLC电源通常采用隔离电源，但其机构及制造工艺因素使其隔离性并不理想。实际上，由于分布参数特别是分布电容的存在，隔离是不可能的。

  (4)来自信号线引入的干扰

  与PLC控制系统连接的各类信号传输线，除了传输有效的各类信号之外，总会有外部干扰信号侵入。此干扰主要有两种途径：一是通过变送器或共用信号仪表的供电电源串入的电网干扰，这往往被忽略；二是信号线受空间电磁辐射感应的干扰，即信号线上的外部感应干扰，这是很严重的。由信号引入干扰会引起I/O信号工作异常和测量精度大大降低，严重时将引起元器件损伤。对于隔离性能差的系统，还将导致信号间互相干扰，引起共地系统总线回流，造成逻辑数据变化、误动和死机。PLC控制系统因信号引入干扰造成I/O模件损坏数相当严重，由此引起系统故障的情况也很多。

Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   GEC Alsthom FV223-C Gecostat Exciter Diode Failure Detector
Pre-Owned
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse Emerson 1C31174G03 Ovation Loop Interface Module
Pre-Owned
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Power-One Emerson WH1D-2FF Ovation Power Supply Module 1X00024H04 Rev   C
Pre-Owned
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Foxboro PSU Programming Panel Assembly D0140ZK-C
Pre-Owned
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Rosemount 3051CD3A22A1AS2B4I5V5 Pressure Transmitter w Remote Seals 10179191
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Perceptron 916-4104 Digital Contour Sensor Rev   9 C0400-X0000-Y0126-Z0287
Pre-Owned
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Perceptron 916-4104 Digital Contour Sensor Rev   6 C0400-X0000-Y0126-Z0287
Pre-Owned
   5  386  17
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Etsi / Bailey Controls CMM11 infi 90 Vibration Monitor Slave Module
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Thermo Electron G4-SB1K-N Load Cell 1000 Pound Capacity
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Bell & Gossett Series 60 172710 Water Circulation Pump 1-1/4X5-1/4
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D MHL366006139 Shunt Trip Circuit Breaker 600 Amps 600VAC Cut Leads
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Unbranded Hitch Bushing for P and H MinePro Services Inc   5-1/8"I  D   7"O  D  
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   ABB 8231101 Series 4500 Analyzer Control Unit
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Siemens 7ML5033-1AA00-1A Multiranger 100 Ultrasonic Liquid Level Monitor
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   General Electric CR305G0** NEMA Size 5 Contactor 75-200 HP 460-480V Coil
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Fisher 11A5332X022 Plug and Stem Assembly
Brand New
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D 3020 CM150X1 PowerLogic Circuit Monitor Series E3
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Rosemount 3051S1CD2A2B11A1AB4E5M5Q4 Pressure Transmitter w/ Remote Seal RS2
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Metso Minerals Dredge Pump Packing Gland 16" X 9-1/2"
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Thomas & Betts DH010H040-TGL-L4E Hazlux 3 Lighting Assembly
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Xycom CPU XVME-688 Processor Module 70688-011
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51305390-300 Control Board UPCU
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Gardner Denver Packing Gland for a Gardner Denver Thomas Dredge Pump
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Advantech TPC-1270H-P2BE Touchscreen Operator Interface Panel
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Xycom XVME-674 CPU Board 70674-098 F/W 4  1D
Pre-Owned
   5  212  42
  
Free Shipping
Only 1 left!
2 Watching
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Yokogawa DX104-1-2 Daqstation Data Acquisition Station
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Allen Bradley 1785-L40B/E and 1785-ENET/A Coupled L01
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Fanuc A20B-1006-0481/02A Servo Controller Board
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D MHL366006139 Shunt Trip Circuit Breaker 600 Amps 600VAC
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Reeves Size 300 Constant Disc Kit 41511265BG
   5  212  42
Buy It Now
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW SKF 6317 NU 324 ECM/C3 Cylindrical Roller Bearing
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D LAL363008041 Shunt Trip Circuit Breaker 300 Amps 600VAC
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   PneumaTech EC-002520 Electrical Time Delay Module 0-10 Minute Range
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Square D LH36400MT I-Line Circuit Breaker 400 Amps 600VAC
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Emerson 1D54561G02 WDPF LIM Assembly Sub 09
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Westinghouse 1D54561G02 WDPF LIM Assembly Sub 09
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Danfoss S150724305 Piston Pump LRR025CLS1417NNN3K2NFA6NPLBNNNNNN
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   General Electric 4  16-350 Magne-Blast Circuit Breaker Rear Short Bushing
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Destaco RTP-400-0-0-0-0 Automatic Tool Changer KFN-RTP200
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   BEC Elektronik AS BUF-121-SIO Operator Interface BEC 121 Dual I/O
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Garlock 23X6426 Split Klozure Oil Seal 21  750" O  D     813" Wide 25202-6426
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Xycom XVME-686 CPU Processor Board 70686-102 Rev   1  2
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Xycom XVME-686 CPU Processor Board 70686-102 Rev   1  3
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Endress + Hauser RSG10-A122A21HB Memo-Graph Chart Recorder
Pre-Owned
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
NEW Ariel B-5582-NN Compressor Suction Valve SUC VLV   140CEX   PC   PRC
   5  212  42
  
Free Shipping
 Watch
Get fast shipping and excellent service when you buy from    Top-rated sellers
Item image
   Honeywell 51304685-100 UCN Advanced Communications Card HDW: N FW: D
Pre-Owned
   5  212  42